We keep things savory here in the GC Meat Labs, so when we’re tasked with appetizers, of course, they need to check that box too. And, since we’ve been on a bacon jam kick this summer, why not use it with a buttery flaky puff pastry and cheese (of course) for a savory bite that vanishes quickly.
We figured out where most people get this wrong, and it’s an easy one to overlook. Skipping the freezer step, even once, turns your neat little spiral into a sad, squished oval. Give the roll 30 to 45 minutes in the freezer, and the knife goes through clean, the layers stay defined, and you pull out exactly the flaky, caramelized savory palmier you were picturing.
🔪 Ingredients for Bacon Jam Palmiers
This is a short list with zero forgiveness on the pastry. Buy the good stuff.
- Frozen puff pastry: One sheet, thawed but still cold. Pepperidge Farm works. Dufour is exceptional if you can find it. All-butter is always worth the extra two dollars.
- Bourbon bacon jam: About half a cup. Our onion bacon jam is built for this. If you’re using store-bought, taste it first — some are sweeter than others and will burn faster at high heat.
- Gruyère: Grate it yourself. Pre-shredded is coated in anti-caking agents that mess with how it melts.
- Egg + water: Your egg wash. One large egg, one tablespoon of water, beaten together. This is what gives the tops that deep golden lacquer.
- Fresh herbs: Thyme, rosemary, or chives for garnish. Optional but they make the finished tray look like you planned this.
- Flour: Just for dusting the work surface so the dough doesn’t stick.
Equipment
- Sharp chef’s knife: Non-negotiable for clean cuts through the frozen log. A serrated bread knife also works if your chef’s knife isn’t razor sharp.
- Parchment-lined baking sheet: The jam bubbles. Not a suggestion.
- Pastry brush: For the egg wash.
📝 How to Make Bacon Jam Palmiers
- Lightly flour your work surface and unfold the puff pastry sheet. If the edges have cracked from thawing, press them back together — they’ll seal during baking. If it’s a round sheet, trim to a rough rectangle.
- Spread the bacon jam in a thin, even layer across the entire surface, leaving a clean half-inch border at all four edges. Thin matters here. Too thick and the log won’t hold its shape; too sparse and you lose the whole reason you’re making this.
- Scatter the grated Gruyère over the jam. Cover generously but leave the same half-inch border. Press the cheese gently so it adheres.
- Roll both long sides toward the center. Work tightly and evenly, rolling until the two sides meet in the middle. Press them together firmly at the seam. This is the point where a loose roll will unravel in the oven — take an extra 10 seconds here.
- Wrap the log in parchment or plastic wrap and freeze for 30 to 45 minutes. The dough needs to be firm enough that a sharp knife passes through without compressing the layers. If you’re working ahead, the log keeps frozen for up to a month.
- Preheat oven to 400°F. Pull the log from the freezer and slice into half-inch rounds with a sharp, confident stroke — hesitation compresses the layers. Arrange on the parchment-lined baking sheet with two inches between each piece. They spread outward as they puff.
- Brush the tops with egg wash. Slide into the oven and bake for 15 to 20 minutes, until puffed and deep amber-brown. Watch closely in the last 3 minutes — the sugar in the jam catches fast and goes from caramelized to scorched in about 90 seconds.
- Let cool on the pan for 5 minutes. They crisp up as they come down to temperature. Scatter with fresh thyme or chives and serve warm or at room temperature.
🔄 Substitutions
- Gruyère for aged sharp cheddar: Works well. Similar melt, slightly less nutty. Avoid anything too young — it’ll be oily.
- Gruyère for Parmesan: A drier, saltier result. The palmiers will be crispier and a bit more intense. Don’t use freshly grated fine powder — it disappears into the jam.
- Gruyère for mozzarella: Do not. Too much moisture. You’ll get soggy layers instead of flaky ones.
- Bourbon bacon jam for fig jam + crumbled bacon: If you want to split the components. Spread a thin layer of fig jam first, then scatter cooked bacon crumbles over it. Not the same depth of flavor but it works in a pinch.
- Homemade puff pastry for store-bought: All-butter store-bought (Dufour) gives you 90% of that result for 10% of the effort. If you’re going homemade, use an all-butter block.
💡 Meat Nerd Tips
- The freezer step is structural, not optional. The water content in puff pastry is what creates the steam that separates the layers at 400°F. If the butter has started to warm and smear before it hits the oven, you’re making crackers, not palmiers. Cold pastry, hot oven. That’s the physics of it.
- Don’t oversauce the center seam. The place where the two rolls meet needs to be pressed together firmly. If there’s a thick stripe of jam right at that joint, it acts as a lubricant and the palmier opens up like a book. Keep the jam thinner toward the center fold than at the edges.
- Batch them for a crowd. Make two or three logs at once and keep them in the freezer. They go directly from frozen to sliced to oven — no thawing needed. Logs done a week in advance and you’re slicing and baking 20 minutes before people arrive.
- Parchment is not optional. The bacon jam will bubble over the edges of the palmier and onto the pan. Without parchment, you’re scrubbing caramelized sugar off sheet metal. With parchment, you lift and toss.
🍽️ What to Serve with Bacon Jam Palmiers
- These are a natural lead-in to anything rich and cold, a sharp cheese board, a glass of Grüner Veltliner, or a cold beer you’ve been looking forward to since noon.
- If you’re building a party spread, pair them with our Stout Beef Hand Pies and the Baked Camembert with Bacon Jam to keep the whole table in the same bourbon-and-pork-fat universe.
- They also work as a standalone cocktail snack. Set them out while dinner finishes, and they’ll be gone before you need them to be.
🧊 Leftovers and Storage
- Room temperature: Airtight container, up to 2 days. They stay passable but lose crunch after a few hours.
- Reheat: 350°F oven, 5 minutes. Gets them back to crispy. The microwave makes them chewy and ruins the layers completely.
- Freeze unbaked logs: Wrap tightly in plastic, then foil. Keeps for up to a month. Slice directly from frozen and add 2 to 3 minutes to the bake time.
- Do not freeze baked palmiers: The pastry structure doesn’t survive thawing. Bake fresh from the frozen log instead.
Have you tried this recipe? Do us a favor and rate the recipe card with the ⭐ ⭐ ⭐ ⭐ ⭐ and drop a comment to help out the next reader.
Bacon Jam Palmiers
Recommended Equipment
- Baking sheet
- Pastry brush
- Parchment paper
Ingredients
bourbon bacon jam
- 1 sheet 1 sheet frozen puff pastry thawed but still cold
- 1/2 cup bourbon bacon jam
- 1 cup Gruyère freshly grated
- 1 large egg
- 1 tbsp water
- flour for dusting
For Garnish (optional)
- fresh thyme, rosemary, or chives chopped
Instructions
Prep the Pastry
- Lightly flour your work surface. Unfold the puff pastry and trim to a clean rectangle if needed. If edges have cracked, press together.
Add the Filling
- Spread bacon jam in a thin, even layer over the entire surface, leaving a 1/2-inch border at the edges. Scatter Gruyère evenly over the jam and press gently to adhere.
Roll and Seal
- Roll both long sides tightly toward the center until they meet. Press the seam firmly together.
Freeze the Log
- Wrap the log in parchment or plastic wrap. Freeze for 30 to 45 minutes until firm.
Slice
- Preheat oven to 400°F. Line a baking sheet with parchment. Remove log from freezer and slice into 1/2-inch rounds with a sharp knife. Arrange 2 inches apart on the prepared baking sheet.
Egg Wash and Bake
- Beat egg with water. Brush tops of palmiers with egg wash. Bake 15 to 20 minutes until puffed and deep golden brown. Watch closely in the final 3 minutes.
Cool and Serve
- Cool on the pan for 5 minutes — they crisp as they cool. Garnish with fresh herbs.
Notes
- Make-ahead: Wrap the unbaked log tightly and freeze up to 1 month. Slice directly from frozen, add 2–3 min to bake time.
- Storage: Airtight container at room temperature up to 2 days. Reheat at 350°F for 5 minutes. Never microwave.
- Cheese swap: Aged sharp cheddar or Parmesan work. Avoid mozzarella (too wet).
- Parchment is mandatory. The jam bubbles over so it makes clean up alot easier.
Nutrition
Bookmark this recipe now!
Quick Summary
Bacon jam palmiers are what happens when you take puff pastry seriously for about 20 minutes of active work. Spread bourbon bacon jam and Gruyère, roll tight, freeze, slice, bake at 400°F until caramelized and flaky. The freezer step is the whole secret — cold dough, hot oven, perfect layers every time.
❓ FAQs
Yes — and this is one of the best make-ahead appetizers you can have in your arsenal. Assemble the log, wrap it tight, and freeze for up to a month. Slice directly from frozen and bake as directed, adding 2 to 3 extra minutes. No need to thaw the log first.
Two likely causes: the two rolls weren’t pressed together firmly enough at the center seam, or there was too much filling in the joint where they meet. Press the seam with intent and keep the jam thinner in the center than at the edges.
You can. Taste it before spreading — commercial versions vary widely in sweetness. A very sweet jam will brown faster, so watch the last few minutes closely. For the best depth of flavor, our homemade bourbon bacon jam is worth making the day before.
Gruyère is the call — it melts clean without going oily, and the nutty flavor matches the bourbon in the jam. An aged sharp cheddar is a solid backup. Skip anything high-moisture like mozzarella; it steams the pastry instead of crisping it.
